Product ID:16081 DARK GRAY ENAMEL, ALKYD, GLOSS
MSDS Date:03/17/1993
FSC:8010
NIIN:00-616-7496
MSDS Number: BRKGQ

CON-LUX COATINGS INC

226 TALMADGE RD
EDISON, NJ 08818-0847
US

Emergency Phone: 908-287-4000

Info Phone: 908-287-4000 / FAX 908-287-9288

Cage: 60189

CON-LUX COATINGS INC

847 EDISON, NJ 08818-0847 US

Telephone: 732-287-4000

Cage: 60189

TITANIUM DIOXIDE ( AS NUISANCE DUST)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: > 1%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: > 1%

ACGIH TLV: 3.5 MG/M3

MINERAL SPIRITS (LEL 1.0)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: > 1%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: IRRITATION OF EYES & SKIN MAY
OCCUR WITH OVEREXPOSURE. CONTINUSED BREATHING OF VAPORS MAY
IRRITATE RESPIRATORY TRACT CAUSING HEADACHE, NAUSEA & DIZZINESS.
CHRONIC: REPORTS HAVE ASSOCIATED REPEATED & PROLONGED
OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN & NERVOUS SYSTEM
DAMAGE.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE RESPIRATION IF
NECESSARY. TREAT SYMPTOMATICALLY. EYE CONTACT: FLUSH IMMEDIATELY
W/LARGE QUANTITIES OF H20 FOR 15 MINUTES MINIMUM. CONSULT A
PHYSICIAN. SKIN CON TACT: WASH AFFECTED AREA W/SOAP & H20. CONSULT
A PHYSICIAN IF IRRITATION PERSISTS. INGESTION: DRINK 1 - 2 GLASSES
OF H20 TO DILUTE DO NOT INDUCE VOMITING. PREVENT ASPIRATION INTO
LUNGS. GET MED ATTN.

Flash Point Method:TCC
Flash Point:105F,41C
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER MIST.
Fire Fighting Procedures:SMOTHER FLAMES WITH ONE OF THE ABOVE
EXTINGUISHING MEDIA. WATER MAY BE USED TO COOL DOWN UNOPENED
CONTAINERS IN VICINITY.
Unusual Fire/Explosion Hazard:CONTAINS FLAMMBLE SOLVENT. DO NOT USE IN
AREAS WHERE SPARKS OR OPEN FLAMES ARE PRESENT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. WEAR
APPROPRIATE PERSONAL PROTECTION EQUIPMENT & APPROVED RESPIRATOR.
PREVENT MATERIAL FROM CONTACTING ANY WATER SOURCES OR SEWERS
LEADING TO SURFACE WATERS.

Handling and Storage Precautions:STORE IN AREAS DESIGNED TO COMPLY WITH
ANSI/NFPA 30 FLAMMABLE & COMBUSTIBLE LIQUIDS CODE.
Other Precautions:GROUND CONTAINERS WHEN POURING LIQUIDS & POWDERS TO
AVOID STATIC CHARGE BUILDUP. DO NOT HANDLE UNTIL MANUFACTURERS
SAFETY PRECAUTION HAVE BEEN READ & UNDERSTOOD. PROVIDE ADEQUATE
VENTILATION & RESPIRA TORY PROTECTION.

Respiratory Protection:IN RESTRICTED VENTILATION AREAS, A NIOSH/MSHA
APPROVED ORGANIC VAPOR RESPIRATOR IS RECOMMENDED. DURING SPRAY
APPLICATION, A RESPIRATOR PROVIDING ORGANIC VAPOR & SPRAY MIST
PROTECTION IS RECOMMENDED UN LESS ENGINEERING CONTROLS ARE
ADEQUATE.
Ventilation:CONFINED AREAS MECHANICAL VENTILATION REQUIRED TO KEEP THE
AIR CONTAMINANT CONCENTRATION BELOW OSHA PERMISSIBLE LIMITS.
Protective Gloves:IMPERVIOUS
Eye Protection:SAFETY EYEWEAR PROTECT FROM SPLASHES
Other Protective Equipment:PREVENT PROLONGED SKIN CONTACT WITH
CONTAMINATED CLOTHING. REMOVE & WASH CONTAMINATED CLOTHING BEFORE
REUSE.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING OR USING
WASHROOM FACILITIES.
Supplemental Safety and Health

HCC:F4
Boiling Pt:B.P. Text:148 TO 323F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:60.70

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, SPARKS OR OPEN FLAMES.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE &
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.